PRODUCTS

  • Flotation of copper sulphide from copper smelter slag

    10-10-2015· Lowest copper recoveries were obtained with alkyl hydroxamate in single collector floation performance. It has been reported that the alkyl hydroxamate is not very selective for sulphide flotation. In case of copper slag most of the copper occur in the form of copper sulphide and shows very low response with alkyl hydroxamate.

    The Recovery of Copper from Smelting Slag by Flotation

    08-02-2017· Aiming at the recovery of copper from smelting slag, a flotation approach was studied. It was found that this slag composed of fine particles with complex association and distribution, in which bornite was the main copper-bearing mineral after a detailed mineralogy analysis via polarizing microscope, SEM and XRD.

    Enhancing the flotation recovery of copper minerals in

    A range of commercial flotation reagents that include xanthates, dithiophosphates, mercaptobenzothiazole, thionocarbamates, fatty acids, sulphides and sulphates were used in the flotation test-work. The copper recoveries obtained in the mill-float stage were between 70 80%. In the second phase of the study, the flotation tailings were further milled to 90% passing 45 microns and floated.

    Optimization of the flotation of copper smelter slags from

    flotation tests which were performed on slag samples from three different sources (TSL furnace, copper converters, reverberatory furnace) to recover the copper minerals. A range of commercial flotation reagents including xanthates, dithiophosphates, mercaptobenzothiazole,

    Enhancing the flotation recovery of copper minerals in

    01-01-2020· Various flotation reagents that are commonly used for copper flotation were identified, selected and used during the flotation test work in order to identify the best reagent best suited to float the copper slags. Potassium amyl xanthate (PAX) and Flotanol CO 7 were used in all tests as the primary collector and frother.

    RECOVERY OF COPPER FROM COPPER SLAG AND COPPER SLAG

    flotation. Low copper extractions both from the slag and the slag flotation tailings indicate that sulphuric acid is not a suitable reagent for leaching these materials, at room temperature. This conclusion is in line with the study by Banza et al. (2002) where the leaching of copper smelter slag with sulphuric acid (500 kg/Mg slag)

    2-Recovery of Copper and Cobalt from Converter Slag with a

    Recovery of Copper and Cobalt from Converter Slag with a New Flotation Method Using H2S 70 sulfuric acids [12, 13] with and without pressure [13], ferric chloride [8, 14, 15], ferric sulfate [7], cyanide, thiosulphate leaching [16], ferric sulfate and ammonia sulfate solutions [7, 12, 17, 18]. In this study, the flotation of converter slag was

    Copper Sulfide Flotation 911 Metallurgist

    13-04-2016· Copper Sulfide Flotation Reagents. Lime is added to the Ball Mill by a Cone Type Dry Reagent Feeder. Other reagents, such as cyanide, xanthate, and a frother are fed and controlled by No. 12A Wet Reagent Feeders to the classifier and to the conditioner ahead of flotation. Sampling. Automatic Samplers are provided for the sampling requirements.

    Recovery of Copper from Reverberatory Copper Slag and

    because copper slag has a bond work index of 22 kWh/t and is thus a very hard slag. The process also has reduced flotation recoveries and requires high flotation reagent consumption. The present work shows that digestion of the milled copper slag slurry with concentrated sulphuric

    Orica’s flotation reagents increase copper recovery rates

    flotation of slow cooled copper slag. Ultimately, the process needed to achieve superior recovery of copper at a natural pH over a specific grind fineness. Xstrata’s key requirements were to: • Identify superior collectors • Reduce reagent costs • Optimise flotation performance • Integrate improvements into existing operations

    The Complete Collection of Copper Beneficiation

    01-07-2020· In the flotation process of copper ore, the beneficiation reagent is an important factor that determines the flotation effect. It is one of the main research directions of mineral processing workers to explore a new copper flotation process and develop new cost-effective and environmentally friendly reagents to improve the utilization rate of copper resources.

    Recovery of Copper from Reverberatory Copper Slag and

    because copper slag has a bond work index of 22 kWh/t and is thus a very hard slag. The process also has reduced flotation recoveries and requires high flotation reagent consumption. The present work shows that digestion of the milled copper slag slurry with concentrated sulphuric

    pper slag flotation chuquicamata Oikodomos Educatie

    Copper Slag Flotation Process Description Flotation process and choosing appropriate reagents recovery of copper is approximately 75 along with copper content in basic copper concentrate of 589 42 leaching analysing the tailing of copper flotation from smelter slag it was noted that there is a significant copper content in it copper.

    2-Recovery of Copper and Cobalt from Converter Slag with a

    Key words: Converter slag, flotation, copper, cobalt, sulphurization. 1. Introduction Copper slag is produced in large amounts in seven copper smelter plants in Chile, and it is estimated that around 4 million tons of slag are disposed every year and another

    Copper Recovery Through Smelter Slag Flotation in

    Copper slag flotation was studied on an industrial scale at a concentrator plant in the region of Atacama, Chile. This study consisted of the physical, chemical, and mineralogical characterization of the copper slag, along with preliminary flotation tests.

    Copper Sulphide Ore Reagents For Copper Flotation

    Copper Sulphide Ore Reagents For Copper Flotation. After two minutes flotation a copper grade of 5.2 per cent with 52 per cent recovery could be attained, against a grade of 2.5 per cent and a recovery of 44 per cent in the case of kax.the efficiency of this new collector has been ascertained on two samples of complex sulphide ores of.

    Copper Slag Flotation Process najlepsze-przepisy.pl

    Flotation reagents copper slag Oricas flotation reagents increase copper recovery rates resulting in a 2M increase in gross revenue flotation of slow cooled copper slag Ultimately the process needed to achieve superior recovery of copper at a natural pH over a specific grind fineness Enhancing the flotation recovery of copper minerals.

    EVALUATION OF ORGANIC CARBON SEPARATION FROM COPPER

    reagent. Keywords: flotation, carbonaceous matter, copper ore Introduction The copper ore located in the for-Sudetic monocline, besides copper and silver, con-tains many other valuable chemical elements. The polymetallic character of the ore and produced by KGHM Polska Miedz SA flotation concentrates influences effective-

    copper slag flotation fajnababka.pl

    Copper Slag Flotation Process Najlepsze Przepisy. Copper Slag Flotation Copper Slag Milling And Flotation Process Enhancing the flotation recovery of copper minerals in 01012020183 The following was used during the milling test work on the slag samples a laboratory scale ball mill 400 mm by 300 mm a

    2-Recovery of Copper and Cobalt from Converter Slag with a

    Key words: Converter slag, flotation, copper, cobalt, sulphurization. 1. Introduction Copper slag is produced in large amounts in seven copper smelter plants in Chile, and it is estimated that around 4 million tons of slag are disposed every year and another

    The Complete Collection of Copper Beneficiation Reagents

    01-07-2020· In the flotation process of copper ore, the beneficiation reagent is an important factor that determines the flotation effect. It is one of the main research directions of mineral processing workers to explore a new copper flotation process and develop new cost-effective and environmentally friendly reagents to improve the utilization rate of copper resources.

    Recovery of Copper from Reverberatory Copper Slag and

    because copper slag has a bond work index of 22 kWh/t and is thus a very hard slag. The process also has reduced flotation recoveries and requires high flotation reagent consumption. The present work shows that digestion of the milled copper slag slurry with concentrated sulphuric

    copper slag flotation agatola.pl

    Recovery of Copper from Copper Smelter Slag by Flotation. The recovery of copper from copper smelter slag utilizing flotation has been studied. A copper smelter slag from the Wang Jiaqiao smelter in Yunnan Province of china, containing 2.76% Cu, 44.41% Fe, 2.34% Zn and 18.4g/t Ag and so on, has been used .The effective factors such as grinding fineness, pH, and the dosage and type of collector

    Copper Sulphide Ore Reagents For Copper Flotation

    Copper Sulphide Ore Reagents For Copper Flotation. After two minutes flotation a copper grade of 5.2 per cent with 52 per cent recovery could be attained, against a grade of 2.5 per cent and a recovery of 44 per cent in the case of kax.the efficiency of this new collector has been ascertained on two samples of complex sulphide ores of.

    Copper Slag Flotation Process najlepsze-przepisy.pl

    Flotation reagents copper slag Oricas flotation reagents increase copper recovery rates resulting in a 2M increase in gross revenue flotation of slow cooled copper slag Ultimately the process needed to achieve superior recovery of copper at a natural pH over a specific grind fineness Enhancing the flotation recovery of copper minerals.

    copper slag flotation plant unc-pro.ch

    Copper Slag Flotation Plant In Pakistan. 2017-10-26 2020420effective flotation of pyrite slag copper and copperzinc ores should be subjected to the study Slag copper different companies differ significantly from each other 12 Typing copper slag Ural region has allowed to identify three main technological type of slag fayaliteferrite ferritefayalitemagnetite and fayalitemagnetite

    EVALUATION OF ORGANIC CARBON SEPARATION FROM COPPER

    reagent. Keywords: flotation, carbonaceous matter, copper ore Introduction The copper ore located in the for-Sudetic monocline, besides copper and silver, con-tains many other valuable chemical elements. The polymetallic character of the ore and produced by KGHM Polska Miedz SA flotation concentrates influences effective-

    Copper Slag Flotation Plant atlantikwallarchief.nl

    Copper Slag Flotation Plant. Copper slag beneficiation mill photos copper slag flotation plant feldspar crusher sales copper slag flotation plant copper slag flotation plant liming excellent mining crushing machinery products or production line design the company is committed to building the chinese brand mine crushing and processing machinery mainly crusher mill.

    copper slag flotation fajnababka.pl

    Copper Slag Flotation Process Najlepsze Przepisy. Copper Slag Flotation Copper Slag Milling And Flotation Process Enhancing the flotation recovery of copper minerals in 01012020183 The following was used during the milling test work on the slag samples a laboratory scale ball mill 400 mm by 300 mm a

    Copper Slag Milling And Flotation Process

    Recovery Of Copper From Reverberatory Copper Slag. The typical process uses crushing milling and flotation These operations create excessive liner wear rates during crushing and milling because the bond work index of copper slag is 22 kWht and this is considered a very hard slag The process also has reduced flotation recoveries and requires high flotation reagent consumption.

    Copper Recovery Through Smelter Slag Flotation in

    Copper slag flotation was studied on an industrial scale at a concentrator plant in the region of Atacama, Chile. This study consisted of the physical, chemical, and mineralogical characterization of the copper slag, along with preliminary flotation tests.

    flotation of copper slag in jersey ra-huerth.de

    Copper Slag Flotation Plant ,The multicell copper slag flotation machine consists of a series of sections located at unique levels A minimum distance among the levels of person sections is 500 mm 1 section can comprise up to three cells The material comes to the flotation cell by way of a feed cell...As a leading global manufacturer of crushing equipment, milling equipment,dressing equipment

    copper slag flotation agatola.pl

    Recovery of Copper from Copper Smelter Slag by Flotation. The recovery of copper from copper smelter slag utilizing flotation has been studied. A copper smelter slag from the Wang Jiaqiao smelter in Yunnan Province of china, containing 2.76% Cu, 44.41% Fe, 2.34% Zn and 18.4g/t Ag and so on, has been used .The effective factors such as grinding fineness, pH, and the dosage and type of collector

    milling and flotation of slow cooled copper slag in south

    Copper Ore Processing Equipment. Capacity: 0.18-7 (m ³/min) Suitable Materials: Copper, zinc, lead, nickel, gold and other non-ferrous metals, ferrous and non-metal. Major Equipment: Jaw crusher, ball mill, sprial classifier, flotation machine, concentrator machine and dryer machine Details; Flotation Machine. Processing Ability: 0.2–16 m³/min Processed Materials: Non-ferrous metal

    Copper Slag Flotation Process najlepsze-przepisy.pl

    Flotation reagents copper slag Oricas flotation reagents increase copper recovery rates resulting in a 2M increase in gross revenue flotation of slow cooled copper slag Ultimately the process needed to achieve superior recovery of copper at a natural pH over a specific grind fineness Enhancing the flotation recovery of copper minerals.

    Flotation Of Copper Slag In Russia ra-warnecke.de

    Copper Slag Flotation Process Description Flotation process and choosing appropriate reagents recovery of copper is approximately 75 along with copper content in basic copper concentrate of 589 42 leaching analysing the tailing of copper flotation from smelter slag it was noted that there is a significant copper content in it copper.

    COPPER Copper production TU Delft

    Beneficiation by froth flotation of ore to give copper concentrate fine concentrate. The hydrophilic gangue minerals remain in the pulp. Organic reagents with sulfur-containing groups at their polar end, ( 95 wt % Cu) and to a copper-rich slag. The two ore types can be smelted together to produce matte and a slag with low copper content.

    copper slag flotation machine opiekundluznika.pl

    Flotation reagents copper slag oricas flotation reagents increase copper recovery rates resulting in a 2m increase in gross revenue flotation of slow cooled copper slag ultimately the process needed to achieve superior recovery of copper at a natural ph over a specific grind fineness enhancing the flotation recovery of copper minerals.

    copper slag flotation fajnababka.pl

    Copper Slag Flotation Process Najlepsze Przepisy. Copper Slag Flotation Copper Slag Milling And Flotation Process Enhancing the flotation recovery of copper minerals in 01012020183 The following was used during the milling test work on the slag samples a laboratory scale ball mill 400 mm by 300 mm a